Gas Safety Risks of Lithium-Ion Battery

Gas Safety Risks of Li-Ion Battery Charging Rooms

Li-Ion Battery Charging Rooms Li-Ion Batteries Charging, Storage Plants Li-Ion Batteries Short Circuit Fires
Li-Ion Batteries Fires Due to Over-Charging Hydrogen Fluoride Gas Threats from Li-Ion Batteries HF TWA: 3 ppm, STEL 6 ppm, NIOSH USA Heavier than Air
  • Li-Ion batteries are now widely being used in mobile phones, electric vehicles, laptops including MW range of Renewable Energy Storage plants, aircraft, submarine, mine-shaft, spacecrafts
  • Li-Ion batteries when overcharged or short circuited are overheated and catch fires
  • Li-Ion battery fires have caused great concern because of risks due to spontaneous fires and intense heat generated by such fires
  • As a result of the above-said a lethal amount of toxic Hydrogen Fluoride Gas, HF is generated
  • HF from Li-Ion battery fires can pose severe gas safety risks in confined spaces like battery charging rooms, renewable energy storage plants in solar or wind power plants
  • The electrolyte in Li-Ion battery is flammable and generally contains Lithium Hexa-Fluoro-Phosphate (LiPF6)
  • In the event of overheating due to overcharging or short circuiting in Li-Ion Batteries backed by high temperature, the electrolyte will vaporise liberating toxic gases like CO, CO2, HF (Hydrogen Fluoride)
  • The moisture and humidity will further exacerbate the situation generating more HF (reaction of LiPF6 with water, humidity) 
  • Typical HF concentration expected can be as high as 20-200 ppm of HF (NIOSH/USA Safety limit, TWA:3 ppm HF, STEL: 6 ppm HF)

Solutions :

  • Continuous monitoring of HF, Hydrogen Fluoride in Toxic Range of NIOSH/USA : 0-10 ppm
  • Continuous monitoring of other toxic gases like CO, CO2 (gases generated due to the combustions
    fires)
  • Continues monitoring of humidity and temperature
  • Other Parameters like: CO, CO2, Temperature, Humidity, VEFSA (Very Early Fire and Smoke Alarm)
Universal Gas Controller Interfaced with Multi Sensor
Universal Gas Controller Interfaced with Multi Sensor

VEFSA : Very Early Fire and Smoke Alarm : For very early fire detection in electrical cabinets, switchgear rooms. Our sensing system is designed to pick up enhanced gas radicals which are liberated during overheating of PCBs, electrical insulation breakdown due to short circuit or earth fault, transformer insulation breakdown, again due to short circuit or earth fault. Please note by the time the conventional fire detection system like VESDA or conventional smoke sensors pick up the smoke, it is already too late. Our VEFSA Gas Radical Sensing System can detect the gas radicals and shut off the mains/power supply thus protecting
millions of dollars of assets 

Ex-Proof Gas Detector
Ex-Proof Gas Detector

Should you have any questions or concerns regarding this matter, please feel free to contact us or reach our experts to info@alviautomation.comsales@gasalarm.com.au

Be sure, Be safe – Gas Detectors and Alarm System

Safe Ripening Chambers

Fixed Gas Alarm Systems for the conservation and ripening process of fruit and vegetables

Ripening in controlled atmosphere Reliable monitoring of CO2 / C2H4 / C2H4O and O2 deficiency

Fresh fruit and vegetables are alive and continue to breathe after the harvest. This leads to oxygen consumption and the formation of carbon dioxide and water vapour. Keeping the products fresh means slowing down the process while maintaining the quality of the product. Gas sensors are just as important as the modern technology of the ripening chambers.

They are required to permanently monitor the various gas concentrations involved in the ripening process. The sensors, controllers and warning devices from MSR-Electronic protect people and equipment effectively and monitor the system as a central point of the entire process. Modern communication technology makes it possible to react quickly.

The innovative compact controller of the PolyGard®2 series from MSR-Electronic is de-signed for connecting up to 10 gas sensors via its own field bus, serves to warn of various gases and is therefore ideal for the application.

The process of banana ripening  is probably the best known and consists of introducing ethylene into the storage room at concentrations around 150–200 ppm to accelerate the natural ethylene production of the banana itself.

Fruit Ripening
Fruit Ripening Chamber 

FEATURES AND BENEFITS:


• Display for all displaying functions, configuration and calibration functions (no tool required)
• Fieldbus connection for up to 10 gas sensors (SB2-Units) with max.900m length
• Hardware and software according to SIL-compliant development process
• Modular technology (pluggable and exchangeable), reverse polarity and overload protected
• Internal function monitoring with integrated hardware watchdog
• 3 relays, 2 transistor outputs, 2 digital inputs
• Various housing types with IP65
• Warning buzzer and status LED for warning, fault, operation and service (optional)
• Operating voltage 230 V AC, with wide range input 100 to 240 V AC (optional), UPS (optional)

Hydrogen Gas Sensor
Ethylene Gas Sensor
Sensor Cartridge
Sensor Cartridge

Should you have any questions or concerns regarding this matter, please feel free to contact us or reach our experts to info@alviautomation.comsales@gasalarm.com.au

Be sure, Be safe – Gas Detectors and Alarm System

Industrial Gas Detection Systems

We ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Industrial Gas Detection Systems, Sensor Detection Systems detects monitor and send the output to  Control Alarm systems for controlling the leakage, to protect the lives and assets.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Description:

All Toxic & Combustible Gas  detector is a highly robust, industrial grade, flameproof/ Explosionproof  Gas Leakage Detection Systems.

The detector is used for online, continuous monitoring of the flammable concentration of Methane Gas in PPM or %Vol terms in ambient air or duct or pipeline. It is ATEX, IECEx certified with SIL 2 safety integrity level for hazardous area installation Zone 1 and 2.

With Benefits:

  • ATEX and IEC Ex certificates MSR-Electronic for electrical Ex protection
  • Metrological test & SIL2 safety functions 4–20 mA, RS485 and relay
  • For zone 1 (and also suitable for zone 2) Type “Ex db” with flame-proof enclosure
  • For zone 2: Type “Ex nA” with flame-proof enclosure
  • Continuous monitoring
  • Microprocessor with 12-bit converter resolution
  • Self-monitoring system
  • Easy calibration
  • Calibration service by exchanging the sensor head
  • Proportional 4–20 mA output
  • Serial interface to the control center
  • Reverse polarity protection
  • Overload protection
  • LCD with status LEDs (optional)
  • Alarm and fault signal relay (optional)

Our customers come from various industries like oil/gas, chemical, manufacturing, petrochemical, pharmaceutical, building, mining, nuclear, steel, defense, power, water, wastewater, mining, cement, dairy, automobile, etc.

Should you have any questions or concerns regarding this matter, please feel free to contact us or reach our experts to info@alviautomation.com

Be sure, Be safe – Gas Detectors and Alarm System

Gas Detection Systems for the Waste Management Sector

We are pleased to introduce our world-class best German Technologies, Our Best Gas Detection Systems for Waste Management Sectors / Industries and Plant.

Waste Management and Waste treatment Industries produce various toxic and explosive gases such as methane, hydrogen sulfide, ammonia, carbon dioxide, carbon monoxide, chlorine, ozone, etc, for all these unwanted hazardous gas it is required to use GasDetection Systems for the Waste Management Sector.

In addition, in confined spaces, the increased formation of toxic gases and the decreased concentration of oxygen make these areas particularly dangerous for workers.

The risk can be evaluated by measuring worker exposure to various gases present in the air in the working areas. The measured concentrations are then compared to the 8-hour time-weighted averages for exposure (TWA) and to recommended exposure limits for shorter time periods (less than 15 minutes).

Several technologies and Gas Detections Systems are there to detect gases present in waste treatment facilities.

For your quick reference we have :

  • We have World Class Best Electrochemical sensors which are used to monitor the presence of oxygen in the air, or the presence of other toxic gases such as CO, H2S, and Cl2 in the environment.
  • We have world-class best Semi-conductor sensors that are used to detect the concentrations of Ammonia, Ethylene in the Environment.
  • We have World Cass Best Catalytic sensors which are used for the detection of explosive gases like CH4, Hydrogen, Pentane Etc.
  • We have also Infrared sensors that are used for the detection of explosive gases such as Methane CH4 or carbon dioxide (CO2) etc.
  • We have complete solutions for the industries – GAS Detection and Control Display Alarm Systems.
  • We also provide Supply, Service, Installation, Commissioning, and Calibrations of our Supplied Systems.

For more details please contact us on : – Info@alviautomation.com 

n-Hexane Gas Detector and Monitor

n-Hexane (C6H14) Gas Detector and Monitor 

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge n-Hexane (C6H14)) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Continue reading “n-Hexane Gas Detector and Monitor”

Hydrogen Gas Detector and Monitor

Hydrogen (H2) Gas Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Hydrogen (H2)Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Continue reading “Hydrogen Gas Detector and Monitor”

Butadiene Gas Detector and Monitor

Butadiene Gas Detector and Monitor 

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Butadiene(C4H6) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

 

Description:

Butadiene(C4H6) detector is a highly robust, industrial grade, flameproof, or explosion-proof gas detector for Butadiene(C4H6) Gas leakage detection.

The detector is used for online, continuous monitoring of the flammable concentration of Methane Gas in PPM or %Vol terms in ambient air or duct or pipeline. It is ATEX, IECEx certified with SIL 2 safety integrity level for hazardous area installation Zone 1 and 2.

With Benefits:

  • ATEX and IEC Ex certificates MSR-Electronic for electrical Ex protection
  • Metrological test & SIL2 safety functions 4–20 mA, RS485 and relay
  • For zone 1 (and also suitable for zone 2) Type “Ex db” with flame-proof enclosure
  • For zone 2: Type “Ex nA” with flame-proof enclosure
  • Continuous monitoring
  • Microprocessor with 12-bit converter resolution
  • Self-monitoring system
  • Easy calibration
  • Calibration service by exchanging the sensor head
  • Proportional 4–20 mA output
  • Serial interface to the control centre
  • Reverse polarity protection
  • Overload protection
  • LCD with status LEDs (optional)
  • Alarm and fault signal relay (optional)

Our Industries:
Our customers come from various industries like oil/gas, chemical, manufacturing, petrochemical, pharmaceutical, building, mining, nuclear, steel, defense, power, water, wastewater, mining, cement, dairy, automobile, etc.

Should you have any questions or concerns regarding this matter, please feel free to contact us or reach our experts to info@alviautomation.comsales@gasalarm.com.au

Be sure, Be safe – Gas Detectors and Alarm System

Ethyl Acetate Gas Detector and Monitor

Ethyl Acetate  (C4H8O2) Gas Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Ethyl Acetate  (C4H8O2)Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Description:

Ethyl Acetate  (C4H8O2) detector is a highly robust, industrial grade, flameproof, or explosion-proof gas detector for Ethyl Acetate  (C4H8O2) Gas leakage detection or LEL monitoring.

The detector is used for online, continuous monitoring of the flammable concentration of Methane Gas in %LEL or %Vol terms in ambient air or duct or pipeline. It is ATEX, IECEx certified with SIL 2 safety integrity level for hazardous area installation Zone 1 and 2.

With Benefits:

  • ATEX and IEC Ex certificates MSR-Electronic for electrical Ex protection
  • Metrological test & SIL2 safety functions 4–20 mA, RS485 and relay
  • For zone 1 (and also suitable for zone 2) Type “Ex db” with flame-proof enclosure
  • For zone 2: Type “Ex nA” with flame-proof enclosure
  • Continuous monitoring
  • Microprocessor with 12-bit converter resolution
  • Self-monitoring system
  • Easy calibration
  • Calibration service by exchanging the sensor head
  • Proportional 4–20 mA output
  • Serial interface to the control centre
  • Reverse polarity protection
  • Overload protection
  • LCD with status LEDs (optional)
  • Alarm and fault signal relay (optional)

Our Industries:
Our customers come from various industries like oil/gas, chemical, manufacturing, petrochemical, pharmaceutical, building, mining, nuclear, steel, defense, power, water, wastewater, mining, cement, dairy, automobile, etc.

Should you have any questions or concerns regarding this matter, please feel free to contact us or reach our experts to info@alviautomation.comsales@gasalarm.com.au

Be sure, Be safe – Gas Detectors and Alarm Systems

 

 

Benzene Gas Detector and Monitor

Benzene (C6H6) Gas Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Benzene (C6H6) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions. Continue reading “Benzene Gas Detector and Monitor”

Petrol Vapours Detector and Monitor

Petrol Vapours Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge  Petrol Vapours Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Description:

Petrol Vapours detector is a highly robust, industrial grade, flameproof, or explosion-proof gas detector for Petrol Vapours Gas leakage detection or LEL monitoring.

The detector is used for online, continuous monitoring of the flammable concentration of Methane Gas in %LEL or %Vol terms in ambient air or duct or pipeline. It is ATEX, IECEx certified with SIL 2 safety integrity level for hazardous area installation Zone 1 and 2.

With Benefits:

  • ATEX and IEC Ex certificates MSR-Electronic for electrical Ex protection
  • Metrological test & SIL2 safety functions 4–20 mA, RS485 and relay
  • For zone 1 (and also suitable for zone 2) Type “Ex db” with flame-proof enclosure
  • For zone 2: Type “Ex nA” with flame-proof enclosure
  • Continuous monitoring
  • Microprocessor with 12-bit converter resolution
  • Self-monitoring system
  • Easy calibration
  • Calibration service by exchanging the sensor head
  • Proportional 4–20 mA output
  • Serial interface to the control centre
  • Reverse polarity protection
  • Overload protection
  • LCD with status LEDs (optional)
  • Alarm and fault signal relay (optional)

Our Industries:
Our customers come from various industries like oil/gas, chemical, manufacturing, petrochemical, pharmaceutical, building, mining, nuclear, steel, defense, power, water, wastewater, mining, cement, dairy, automobile, etc.

Should you have any questions or concerns regarding this matter, please feel free to contact us or reach our experts to info@alviautomation.comsales@gasalarm.com.au

Be sure, Be safe – Gas Detectors and Alarm Systems

Ethyl Alcohol Gas Detector and Monitor

Ethyl Alcohol (C2H5OH) Gas Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Ethyl Alcohol (C2H5OH) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions. Continue reading “Ethyl Alcohol Gas Detector and Monitor”

Ethane Gas Detector and Monitor

Ethane (C2H6) Gas Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Ethane (C2H6) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Description:

Ethane (C2H6) detector is a highly robust, industrial grade, flameproof, or explosion-proof gas detector for Ethane (C2H6) Gas leakage detection or LEL monitoring.

The detector is used for online, continuous monitoring of the flammable concentration of Methane Gas in %LEL or %Vol terms in ambient air or duct or pipeline. It is ATEX, IECEx certified with SIL 2 safety integrity level for hazardous area installation Zone 1 and 2.

With Benefits:

  • ATEX and IEC Ex certificates MSR-Electronic for electrical Ex protection
  • Metrological test & SIL2 safety functions 4–20 mA, RS485 and relay
  • For zone 1 (and also suitable for zone 2) Type “Ex db” with flame-proof enclosure
  • For zone 2: Type “Ex nA” with flame-proof enclosure
  • Continuous monitoring
  • Microprocessor with 12-bit converter resolution
  • Self-monitoring system
  • Easy calibration
  • Calibration service by exchanging the sensor head
  • Proportional 4–20 mA output
  • Serial interface to the control centre
  • Reverse polarity protection
  • Overload protection
  • LCD with status LEDs (optional)
  • Alarm and fault signal relay (optional)

Our Industries:
Our customers come from various industries like oil/gas, chemical, manufacturing, petrochemical, pharmaceutical, building, mining, nuclear, steel, defense, power, water, wastewater, mining, cement, dairy, automobile, etc.

Should you have any questions or concerns regarding this matter, please feel free to contact us or reach our experts to info@alviautomation.comsales@gasalarm.com.au

Be sure, Be safe – Gas Detectors and Alarm Systems

 

Continue reading “Ethane Gas Detector and Monitor”

Sulphur Dioxide Gas Detector and Monitor

Sulphur Dioxide Gas Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Sulphur Dioxide (SO2) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Continue reading “Sulphur Dioxide Gas Detector and Monitor”

Hydrogen Gas Detector and Monitor

Hydrogen Gas Detector and Monitor In PPM

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Hydrogen (H2) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions.

Continue reading “Hydrogen Gas Detector and Monitor”

Cyclohexane Gas Detector and Monitor

Cyclohexane (C6H12) Gas Detector and Monitor

ALVI Automation (India) Pvt Ltd, a Division of ALVI Technology Pty Ltd, Australia ( Td/As Gas Alarm Systems) is pleased to introduce our world-class cutting edge Cyclohexane (C6H12) Gas Detector and Monitor.

We are involved with designing, engineering, implementing, calibrating in the field of Gas Detection Systems, Instrumentation, Field devices, and Automation and several automation industries in the Australasian region including now in India. Our mission is to grow consistently using the best global technologies in products and services offered to customers. We aim to serve and maintain long term relationships by providing the most cost-effective appropriate solutions. Continue reading “Cyclohexane Gas Detector and Monitor”